The increased demand for machinery and transport has led to an overwhelming increase in the use of fossil fuels in the last century. Concerning the economic and environmental concern, macroalgae with high fermentable polysaccharide content (mainly mannitol, cellulose and laminarin), can serve as an excellent alternative to food crops for bioethanol production, a renewable liquid fuel. In this study, Saccharina latissima, a brown macroalgae readily available on the Norwegian coast was used as the carbohydrate source for the fermentative production of bioethanol. The macroalgae harvested was found to contain 31.31 ± 1.73 g of reducing sugars per 100 g of dry Saccharina latissima upon enzymatic hydrolysis. The subsequent fermentation with Saccharomyces cerevisiae produced an ethanol yield of 0.42 g of ethanol per g of reducing sugar, resulting in a fermentation efficiency of 84% as compared to the theoretical maximum. Using these results, an evaluation of the fermentation process has demonstrated that the brown macroalgae Saccharina latissima could become a viable bioethanol source in the future.
Recent increased environmental concerns globally have resulted in an increased interest in developing economically viable methods for producing alternative renewable fuels for transportation. Biofuels like biodiesel, bioethanol, and biogas are considered to be promising fuel sources due to their sustainability, adaptability and low environmental impact [
With the excessive use of pesticides and fertilizer in such terrestrial substrate production, concerns for the environment are rising. The production of ethanol from such substrates also has many hurdles such as high cost of production, structural characteristics, geographic latitude and limited yield [
An alternative to terrestrial substrates is the use of third generation marine substrates like seaweeds (photosynthetic organisms) for bioethanol production [
In Nordic countries, where significant levels of terrestrial agriculture are not possible due to the winter climate, macroalgae offers a feasible alternative. For example, Norway has an extensive coastline of relatively warm water (considering the latitude) due to the Gulf stream, providing perfect growing conditions for the largely abundant carbohydrate-rich (laminarin, mannitol and alginate) sugar kelp Saccharina latissima [
In this study, S. latissima from Trondheimsfjord, Norway, was used for the production of bioethanol from their glucose, laminarin and mannitol (fermentable)
Substrate | Average yield (kg/ha/year) | Dry weight of hydrolysable carbohydrates (kg/ha/year) |
---|---|---|
Wheat (grain) | 2800 | 1560 |
Maize (kernal) | 4815 | 3100 |
Sugar beet | 47,070 | 8825 |
Sugar cane | 68,260 | 11,600 |
Macroalgae [ | 75,000 | 4500 |
Data was obtained from [
carbohydrates. Additionally, a straight-forward carbohydrate extraction method was used to lower potential process costs. An evaluation of the process was developed to demonstrate that the brown macroalgae Saccharina latissima could become an economically viable bioethanol source in Nordic countries.
S. latissimi, an abundant macroalgae found in large numbers along the Norwegian west coast, was collected from Trondheimsfjord (N 63˚26'56", E 10˚10'48") near Trondheim, Norway in August of 2017. The macroalgae were subsequently washed using tap water to remove particulates from the surface. S. latissima was then milled using a tabletop blender with 10 mL of deionized water per 1 kg of macroalgae to produce a dense macroalgae pulp. The pulp was dried for 48 h at 30˚C and then stored in airtight plastic bags in a dry location for further use.
Commercial β-glucanase (G4423) from Trichoderma longibrachiatum (Sigma Aldrich, Germany) was used during enzymatic hydrolysis. This was an enzymatic mixture of β-1-3/1-4-glucanase, xylanase, cellulase, β-glucosidase, β-xylosidase, α-˪-arabinofuranosidase and amylase activities. The macroalgae pulp (10% w/v) was suspended in 0.15 M sodium carbonate (Na2CO3) solution to a volume of 25 L at a starting pH of 9.0 in a stirred tank (CE640, Gunt, Germany) for 2 h at 50˚C. After 2 h, the pH was adjusted to 6 using HCl acid solution. Then 5 mg of enzyme mix per g of macroalgae dry weight was added to the solution, and left in the stirred tank for 48 h. Samples were taken every 12 h and analyzed for glucose concentration using a hexokinase glucose assay kit (GAHK20-1KT, Sigma, Germany).
Total carbohydrates, reducing sugar and glucose content were both determined by acidic treatment of pre-hydrolysis dry biomass. Biomass (0.5 g) was treated with 5 mL of 72% (v/v) H2SO4 at room temperature for 30 minutes with constant stirring via a magnetic stirrer. The sample was then diluted to a volume of 50 mL with deionized water, then autoclaved at 121˚C for 30 minutes. Once cooled, NaOH was added to the sample to reach a pH of 7.5. The total carbohydrates in the sample were then determined by using a phenol-sulfuric acid method [
Ethanol concentration was determined using spectrophotometric measurements at 267 nm in a potassium dichromate and perchloric acid solution [
Saccharomyces cerevisiae was chosen for the fermentation experiments as it is a well understood fermentative organism. The organism was supplied with the fermentation equipment (Gunt, Germany). The 25 L of hydrolysate was used in the fermentation tank as the substrate (CE640, Gunt, Germany). 1 g of yeast per L of hydrolysate was added, along with 0.3% (w/v) of yeast extract and 1% (w/v) peptone and adjusted to a pH of 6.8 to support yeast growth. Fermentation was performed at 30˚C for 48 hours. The reducing sugar and ethanol content of the fermented hydrolysate was measured at 12 h intervals throughout the fermentation. Samples were centrifuged at 10,000 × g for 15 minutes at 4˚C, and the supernatant removed for analysis. Reducing sugars in the supernatant were determined using a dinitrosalicylic acid method [
All experiments within this study were conducted in triplicate with the results displayed as mean values ± the standard deviation.
The sugar kelp S. latissima (
The total carbohydrate, reducing sugar and post-hydrolysis glucose yield was determined using samples collected in August of 2017 (
Carbohydrate group | Relative percentage of dry weight |
---|---|
Total carbohydrates | 58 ± 2.6 |
Total reducing sugars | 37 ± 1.1 |
Glucose (pre-hydrolysis | 11 ± 1.2 |
latissima. The reducing sugar content was 37% ± 1.1% of the dry weight of S. latissima, whereas content was 11% ± 1.2% of the dry weight of S. latissima. This is within the expected range of carbohydrate composition based on similar research of S. latissima [
The enzymatic hydrolysis of S. latissima was undertaken to hydrolyze the storage carbohydrates into reducing sugars during a two h macroalgae lysis step, followed by a 48 h enzymatic hydrolysis step for later use in fermentation. An enzymatic mixture of β-1-3/1-4-glucanase, xylanase, cellulase, β-glucosidase, β-xylosidase, α-˪-arabinofuranosidase, and amylases was used. The macroalgae pulp was suspended in 0.15 M sodium carbonate (Na2CO3) solution at a starting pH of 9.0 in a stirred tank. Measurements of the reducing sugar concentration were obtained every 12 h throughout the hydrolysis process.
The initial macroalgae lysis step liberated 9.18 ± 1.21 g/L of reducing sugar. The following enzymatic saccharification during the hydrolysis process yielded a further 22.13 ± 1.43 g/L after 48 h (
The maximum rate of enzymatic saccharification of the macroalgae was observed after 2 h of incubation (
The fermentation of S. latissima was performed at 30˚C for a period of 48 h. The hydrolysate was used as the bioethanol fermentation substrate. The yeast Saccharomyces cerevisiae was used for the fermentation process, with the maximum theoretical ethanol yield of 0.51 g per g of reducing sugar. Measurements of the reducing sugar and ethanol (
Time (h) | Total sugar concentration (g/L) | Sugar released via hydrolysis (g/L) | Saccharification rate (g/L) |
---|---|---|---|
0 | 9.18 ± 1.21 | 0 | 0 |
12 | 18.50 ± 1.41 | 9.32 ± 0.98 | 0.78 ± 0.06 |
24 | 26.19 ± 1.78 | 17.61 ± 1.34 | 0.69 ± 0.02 |
36 | 28.44 ± 1.65 | 20.26 ± 1.41 | 0.22 ± 0.03 |
48 | 31.31 ± 1.73 | 22.13 ± 1.43 | 0.16 ± 0.02 |
was reached after 36 h, at 13.02 ± 0.61 g/L. With the initial glucose concentration of 31.31 ± 1.73 g/L, the maximum ethanol yield from S. latissima was 0.42 g ethanol per 1 g of reducing sugar, 84% of the theoretical yield.
Time (h) | Total sugar concentration (g/L) | Ethanol concentration (g/L) | Theoretical yield (g/L) | Efficiency (%) |
---|---|---|---|---|
0 | 31.31 ± 1.73 | 0 | 0 | 0 |
12 | 15.83 ± 1.21 | 6.16 ± 0.32 | 7.74 | 40 |
24 | 6.59 ± 0.78 | 10.98 ± 0.56 | 12.36 | 71 |
36 | 1.56 ± 0.62 | 13.02 ± 0.61 | 14.88 | 84 |
48 | 0.2 ± 0.17 | 12.83 ± 0.55 | 15.56 | 82 |
The yield observed in this study is amongst the higher known yields as compared to other observations made when using macroalgae as the bioethanol substrate (
The ethanol yield observed in this study is comparable with the ethanol yields observed in lignocellulosic materials. Maize was observed to produce 0.48 g ethanol per 1 g of glucose [
Our results from S. latissima fermentation observed when extracting with sodium carbonate that by using 1 kg of wet S. latissima as the initial biomass, the amount of reducing sugars available was 31.3 g, which can then be fermented into ~ 13 g of ethanol. This carbohydrate-rich macroalgae could be used as the
Macroalgae | Ethanol yield (g/g sugar) | Reference |
---|---|---|
Saccharina japonica | 0.41 | [ |
Sargassum sagamianum | 0.38 | [ |
Saccharina japonica | 0.17 | [ |
Kappaphycus alverzii | 0.39 | [ |
Laminaria japonica | 0.41 | [ |
Gracilaria verrucosa | 0.43 | [ |
Kappaphycus alverzii | 0.37 | [ |
Gelidium amansii | 0.38 | [ |
Ulva fasciata | 0.45 | [ |
Gracilaria salicornia | 0.08 | [ |
Saccharina japonica | 0.41 | [ |
Ulva pertusa | 0.38 | [ |
Alaria crassifolia | 0.28 | [ |
Gelidium elegans | 0.38 | [ |
Sargassum sagamianum | 0.13 - 0.23 | [ |
raw material for bioethanol production, opening up further economic opportunities in aquaculture. By using macroalgae for the production of bioethanol, the requirement for fresh water, fertilizers and agricultural land for bioethanol production will significantly reduce. Furthermore, Nordic countries will be able to produce bioethanol locally, previously unfavorable due to the limited amount of agricultural land available, from naturally occurring S. latissima.
The cost of processing macroalgae for ethanol production can be kept low by employing cost-effective processing methods as used in this study; however, the cost of harvesting large quantities of macroalgae, as well as its delivery to the fermentation plant, are still significant barriers that require attention for the implementation of this technology at an industrial scale.
This study has demonstrated the potential for S. latissima as biomass for the production of bioethanol. This could also be linked to current alginate extraction industries to form an S. latissima-based biorefinery in Nordic countries. The ethanol yield observed was among the higher ethanol yields reported in the literature, suggesting S. latissima could be significant biomass for bioethanol production in Norway. The vast coastlines in Nordic countries like Norway provide an extensive area for macroalgae production, in a natural, sustainable manner. Not only does the use of macroalgae from the ocean help reduce ocean acidification and mitigate climate change, but it also separated bioethanol biomass production from terrestrial agriculture that is essential for food production.
Jacob Lamb acknowledges the support from the ENERSENSE research initiative, and his research was supported by a post-doctoral fellowship from the Norwegian University of Science and Technology―NTNU.
Lamb, J.J., Sarker, S., Hjelme, D.R. and Lien, K.M. (2018) Fermentative Bioethanol Production Using Enzymatically Hydrolysed Saccharina latissima. Advances in Microbiology, 8, 378-389. https://doi.org/10.4236/aim.2018.85025